Optimizing Waste Heat Recovery with a Triple Combined Power Cycle

Authors

  • Alperen Tozlu Bayburt University, Department of Electricity and Energy, 69100, Bayburt - Türkiye
  • Emrah Özahi Gaziantep University Mechanical Engineering Department

DOI:

https://doi.org/10.22399/ijcesen.738

Keywords:

Waste Heat Recovery, Triple Combined Cycle, Energy Efficiency

Abstract

This study aims to utilize waste heat released from an industrial facility at 566 °C and 1.9 bar pressure to generate additional power for the facility. The goal is to reduce the environmental impact of waste heat while enhancing energy efficiency through the application of a triple combined cycle. Initially, the high-temperature waste heat is employed as a thermal source in a gas turbine cycle. The waste heat from the gas turbine is then transferred to an organic Rankine cycle (ORC), where it is used to generate low-temperature steam. In the final stage, the remaining waste heat is harnessed in a Kalina cycle to produce additional power. This triple combined cycle allows for the efficient utilization of waste heat across different temperature ranges, minimizing its environmental impact. The proposed system not only increases the facility's energy output but also mitigates the adverse environmental effects of waste heat. The results demonstrate that the system offers an effective solution for waste heat recovery. Using the model, an additional power of 1688 kW can be produced, which contributes 29.82 % to the actual system.

References

A. Tozlu, E. Özahi, and A. Abuşoʇlu, “Waste to energy technologies for municipal solid waste management in Gaziantep,” Renewable and Sustainable Energy Reviews, vol. 54, 2016, doi: 10.1016/j.rser.2015.10.097.

A. Tozlu, A. Abuşoǧlu, and E. Özahi, “Thermoeconomic analysis and assessment of Gaziantep municipal solid waste power plant,” Acta Phys Pol A, vol. 132, no. 3, 2017, doi: 10.12693/APhysPolA.132.513.

A. Tozlu, A. Abuşoğlu, and E. Özahi, “Thermoeconomic analysis and optimization of a Re-compression supercritical CO2cycle using waste heat of Gaziantep Municipal Solid Waste Power Plant,” Energy, vol. 143, 2018, doi: 10.1016/j.energy.2017.10.120.

E. Özahi, A. Tozlu, and A. Abuşoǧlu, “Thermodynamic performance assessment of different fluids in a typical organic Rankine cycle for usage in municipal solid waste power plant,” Acta Phys Pol A, vol. 132, no. 3, 2017, doi: 10.12693/APhysPolA.132.807.

E. Özahi, A. Tozlu, and A. Abuşoğlu, “Thermoeconomic multi-objective optimization of an organic Rankine cycle (ORC) adapted to an existing solid waste power plant,” Energy Convers Manag, vol. 168, 2018, doi: 10.1016/j.enconman.2018.04.103.

E. Özahi and A. Tozlu, “Optimization of an adapted Kalina cycle to an actual municipal solid waste power plant by using NSGA-II method,” Renew Energy, vol. 149, 2020, doi: 10.1016/j.renene.2019.10.102.

K. AI, “Combined-Cycle System With Novel Bottoming Cycle,” J Eng Gas Turbine Power, vol. 106, no. 4, pp. 737–42, 1984, doi: 10.1115/1.3239632.

D. Bonalumi, P. Bombarda, and C. M. Invernizzi, “Potential Performance of Environmental Friendly Application of ORC and Flash Technology in Geothermal Power Plants,” Energy Procedia, 2017, doi: 10.1016/j.egypro.2017.09.114.

C. Eymelet al., “Exergetic and economic comparison of ORC and Kalina cycle for low temperature enhanced geothermal system in Brazil,” ApplThermEng, vol. 52, no. 1, pp. 109–119, 2013, doi: 10.1016/j.applthermaleng.2012.11.012.

S. Ogriseck, “Integration of Kalina cycle in a combined heat and power plant, a case study,” ApplThermEng, vol. 29, no. 14–15, pp. 2843–2848, 2009, doi: 10.1016/j.applthermaleng.2009.02.006.

R. K. Jurgen, “The promise of the Kalina cycle: Using an ammonia-water mixture, the Kalina steam cycle may permit thermal-mechanical-electrical energy conversion efficiencies of 45 percent,” IEEE Spectr, vol. 23, no. 4, pp. 68–70, 2013, doi: 10.1109/mspec.1986.6370873.

M. Arshad et al., “Green Electricity Generation From Biogas of Cattle Manure: An Assessment of Potential and Feasibility in Pakistan,” Front Energy Res, 2022, doi: 10.3389/fenrg.2022.911485.

O. Güngör, A. Tozlu, and C. Arslantürk, “Assessment of waste-to-energy potential of ELT management: An actual case study for Erzincan,” Environ Prog Sustain Energy, vol. 41, no. 2, Mar. 2022, doi: 10.1002/ep.13760.

X. Lu, A. Watson, and J. Deans, “Analysis of the Thermodynamic Performance of Kalina Cycle System 11 (KCS11) for Geothermal Power Plant: Comparison With Kawerau ORMAT Binary Plant,” pp. 357–358, 2010, doi: 10.1115/es2009-90165.

W. R. Wagar, C. Zamfirescu, and I. Dincer, “Thermodynamic performance assessment of an ammonia-water Rankine cycle for power and heat production,” Energy Convers Manag, vol. 51, no. 12, pp. 2501–2509, 2010, doi: 10.1016/j.enconman.2010.05.014.

R. DiPippo, “Second Law assessment of binary plants generating power from low-temperature geothermal fluids,” Geothermics, vol. 33, no. 5, pp. 565–586, 2004, doi: 10.1016/j.geothermics.2003.10.003.

E. Özahi, A. Tozlu, and A. Abuşoğlu, “Organik Rankine çevrimientegreedilmiş S-CO2 kullanılanbirgaztürbinçevriminintermodinamikvetermoekonomikanalizi,” Gazi ÜniversitesiMühendislik-MimarlıkFakültesiDergisi, vol. 2018, no. 2018, Apr. 2018, doi: 10.17341/gazimmfd.416394.

A. Tozlu, A. Abuşoğlu, and E. Özahi, “Thermoeconomic analysis and optimization of a Re-compression supercritical CO2 cycle using waste heat of Gaziantep Municipal Solid Waste Power Plant,” Energy, vol. 143, pp. 168–180, Jan. 2018, doi: 10.1016/j.energy.2017.10.120.

K. H. Kim, C. H. Han, and K. Kim, “Effects of ammonia concentration on the thermodynamic performances of ammonia-water based power cycles,” Thermochim Acta, vol. 530, pp. 7–16, 2012, doi: 10.1016/j.tca.2011.11.028.

A. I. Kalina, “Generaton of Energy by Means of a Working Fluid and Regeneration of a Working Fluid,” 1982.

P. Roy, M. Désilets, N. Galanis, H. Nesreddine, and E. Cayer, “Thermodynamic analysis of a power cycle using a low-temperature source and a binary NH3–H2O mixture as working fluid,” International Journal of Thermal Sciences, vol. 49, no. 1, pp. 48–58, Jan. 2010, doi: 10.1016/j.ijthermalsci.2009.05.014.

Downloads

Published

2025-09-17

How to Cite

Tozlu, A., & Özahi, E. (2025). Optimizing Waste Heat Recovery with a Triple Combined Power Cycle. International Journal of Computational and Experimental Science and Engineering, 11(3). https://doi.org/10.22399/ijcesen.738

Issue

Section

Research Article